Char-Broil 466244012 Commercial C-46DL Betriebsanweisung

Char-Broil C ommercial C -46DLAssembly instructions © 2011 PRODUCT GUIDEMODEL 466244012 © 2011 Char-Broil, LLC Columbus, GA 31902Printed in

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in

Safety TipssBefore opening LP cylinder valve, check the coupling nut for tightness.sWhen grill is not in use, turn off all control knobs and LP cylind

Burner Flame Check• Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW position

Cleaning the Burner AssemblyFollow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn g

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this pr

PARTS LISTNOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the

PARTS DIAGRAM16MMACHIJKCRUSDDEGQXXXXXWTJFFKKHHLLJJGGLMYRRRRSSTTUUXXZBFNNNNOOYYYYWWWPVVVOOOOPPQQQQQQQQWWEEKKAANNCCBBDDIIWW

21/4-20x1/2” screw1Attach side panels to bottom shelf using three 1/4-20x1/2” screws, 7mm lock washers, and 7mm flat washers per panel.IMPORTANT: Pa

34This step requires two people to lift and position grill head onto cart. Carefully lower the grill head onto the cart, aligning slots at bottom of g

6On back of grill, place upper back panel between side panels and above lower back panel. Secure upper back panel, in lower holes, using one 1/4-20x1½

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.2. An LP cylinder not connected fo

78Insert flange on left side shelf into side shelf brackets on side of firebox. Fascia, left sideburner shelfLeft sideburner shelfFlangeintoBracketsBr

910Insert sideburner burner into left shelf.shelf, shown A.The stud on bottom of burner fits into rear small hole in sideburner drip pan onSecure burn

1211Inside of cart, insert left and right grease tray rails into slots beneath grease tray opening in upper back panel, shown A. Attach right and lef

1314Insert hinge pin on bottom of doors into hole in bottom shelf. Press upper hinge pin in front brace, align hinge hole on top of door, and release

Place cooking grates onto the firebox as shown. Insert the three wire ends at rear of warming rack into holes in back of firebox. Front wires of warmi

On back of grill, slide grease tray into opening in upper back panel.CAUTIONFailure to install grease tray will cause hot grease to drip from bottom o

Unscrew on cart right side panel. Insert AA battery into ignitor, negative (—) end first.Replace the cap. electronic ignition cap –1926AA BatteryE

DANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.EmergenciesProblemGas leaking from cracked/cut/

Troubleshooting (continued)ProblemBurner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also)Burner(s) will notmatch light.

Troubleshooting - Electronic IgnitionProblem (Ignition)SECTION INo sparks appear at any electrodes when Electronic Ignition Buttonis pressed; no noise

WARNINGCALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause

NOTES30

31 First Name | Nombre | Prénom Initial | Inicial | Initiale Last Name | Apellido | Nom de FamillieAddress (number & street) | Dirección (número y

4First Time UseRead your Assembly Manual and ensure the grill is put together properly. Remove all Point-of-Purchase advertising material from all gr

5Outdoor grilling is really quite simple. You'll succeed with burgers, dogs, or steaks usually on your very first try. With experience, you wil

6Cooking on your new grill is a hands-on experience, and it is recommended to remain outside with your grill while cooking. Grilling can be affected

7Why Clean?We've all heard the saying 'An ounce of prevention is worth a pound of cure'. This is great advice when it comes to keeping

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or impr

WARNINGIf “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department!Connecting Regulator to the